Airworthiness Directive · Amendment 39-21814 · Aircraft fuel distribution, and 2497, electrical power system wiring
Pacific Aerospace Limited Airplanes
This AD applies to Pacific Aerospace Limited Model 750XL airplanes, serial numbers 101 through 215 inclusive, 220, 8001, and 8002, certificated in any category, that are fitted with an air conditioner and/or a standby alternator, including airplanes configured for the installation of an air conditioner and/or a standby alternator, as shown in Figure 1 of Part A in Pacific Aerospace Mandatory Service Bulletin PACSB/XL/113, Issue 2, dated March 8, 2019 (MSB PACSB/XL/113, Issue 2).
The FAA is adopting a new airworthiness directive (AD) for certain Pacific Aerospace Limited Model 750XL airplanes. This AD was prompted by mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI identifies the unsafe condition as chafing of the engine fuel feed line hoses. This AD requires inspecting the engine fuel feed line hoses and the electrical wiring and rerouting all fuel lines. The FAA is issuing this AD to address the unsafe condition on these products.
Within 50 hours time-in-service (TIS) or at the next annual inspection after the effective date of this AD, whichever occurs later, inspect the engine fuel feed line hoses and the electrical wiring for chafing and damage in accordance with the Accomplishment Instructions, Part A steps (3) and (4), in MSB PACSB/XL/113, Issue 2.
(1) If there is any chafing or damage that penetrates the orange outer covering of the fuel line fire sleeve or if there is any chafed or damaged electrical wiring, before further flight, inspect the fuel hose for chafing, replace any chafed fire sleeve or fuel hose, and reroute all fuel lines in accordance with the Accomplishment Instructions, Part B, in MSB PACSB/XL/113, Issue 2.
(2) If there are no chafed or damaged engine fuel feed line hoses and no chafed or damaged electrical wiring, within 50 hours TIS or at the next annual inspection, whichever occurs later, reroute all fuel lines in accordance with the Accomplishment Instructions, Part B, in MSB PACSB/XL/113, Issue 2.
The aircraft, engines and makers this AD names, by the model designations in its text. A model listed here may still be outside the AD's serial ranges.
Aircraft
