Airworthiness Directive · Amendment 39-21517 · Reciprocating engine oil system
Austro Engine GmbH Engines
Superseded. A later AD replaced this one: AD 2021-24-10. Comply with the one in force.
This AD applies to all Austro Engine GmbH E4 and E4P model diesel piston engines.
The FAA is adopting a new airworthiness directive (AD) for all Austro Engine GmbH E4 and E4P model diesel piston engines. This AD was prompted by reports of an oil pump blockage on E4 model diesel piston engines. This AD requires replacing a certain oil pump as well as the oil filter and engine oil. The FAA is issuing this AD to address the unsafe condition on these products.
Within the compliance time specified in Table 1 to paragraph (g) of this AD:
(1) Remove the oil pump, part number (P/N) E4A-50-000-BHY, from service and replace with a part eligible for installation using the Accomplishment/Instructions, paragraph 2.2.1 or paragraph 2.2.2, of Austro Engine GmbH Mandatory Service Bulletin No. MSB-E4-030/4, Revision 4, dated March 30, 2021 (the MSB), as applicable.
(2) Replace the oil filter and engine oil using the Accomplishment/Instructions, paragraph 2.2.1 or paragraph 2.2.2, of the MSB, as applicable.
The reporting requirements in the Accomplishment/Instructions, paragraph 2.2., of the MSB, are not required by this AD.
After the effective date of this AD, do not install onto any engine an oil pump having a P/N and serial number (S/N) listed in paragraph 1.2., Engines Affected, of the MSB.
For the purpose of this AD:
(1) Group 1 engines are E4 model diesel piston engines in configuration “-A” that are installed on single-engine airplanes.
(2) Group 2 engines are E4 model diesel piston engines in configuration “-B” or “-C” and E4P model diesel piston engines that are installed on twin-engine airplanes.
(3) A part eligible for installation is an oil pump with a P/N and S/N that is not listed in paragraph 1.2., Engines Affected, of the MSB.
The aircraft, engines and makers this AD names, by the model designations in its text. A model listed here may still be outside the AD's serial ranges.
