Airworthiness Directive · Amendment 39-15847 · Wings
Empresa Brasileira de Aeronautica S.A. (EMBRAER) Model ERJ 190 Airplanes
This AD applies to EMBRAER Model ERJ 190-100 STD, -100 LR, -100 IGW, -100ECJ, -200 STD, -200 LR, and -200 IGW airplanes, certificated in any category, serial numbers 19000004, 19000006 through 19000028 inclusive, and 19000030 through 19000039 inclusive.
We are adopting a new airworthiness directive (AD) for the products listed above. This AD results from mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:
Unless already done: Prior to the accumulation of 5,000 total flight cycles, or within 500 flight cycles after the effective date of this AD, whichever occurs later, do the following actions.
(1) Spot-face the lower wing stringers between ribs 7 and 10 on both wings by changing their run out in accordance with the Accomplishment Instructions of EMBRAER Service Bulletin 190-57-0005, Revision 01, dated October 27, 2006; or Revision 02, dated May 27, 2008.
(2) Do a dye-penetrant inspection for cracking of the reworked stringers in accordance with the Accomplishment Instructions of EMBRAER Service Bulletin 190-57-0005, Revision 01, dated October 27, 2006; or an eddy current inspection for cracking of the reworked stringers in accordance with the Accomplishment Instructions of EMBRAER Service Bulletin 190-57-0005, Revision 02, dated May 27, 2008.
(i) If no cracking is detected: Before further flight, flap-peen or shot-peen the stringer reworked area following the parameters indicated in the Accomplishment Instructions of EMBRAER Service Bulletin 190-57-0005, Revision 01, dated October 27, 2006; or Revision 02, dated May 27, 2008.
(ii) If any cracking is detected: Before further flight, repair the airplane using a method approved by either the Manager, International Branch, ANM-116, Transport Airplane Directorate, FAA; or the ANAC (or its delegated agent).
(3) Actions done before the effective date of this AD in accordance with EMBRAER Service Bulletin 190-57-0005, dated October 10, 2006; are acceptable for compliance with the corresponding requirements of paragraph (f) of this AD.
Note 1: This AD differs from the MCAI and/or service information as follows: No differences.
The aircraft, engines and makers this AD names, by the model designations in its text. A model listed here may still be outside the AD's serial ranges.
Aircraft
