Airworthiness Directive · Amendment 39-15503 · Fuel
Construcciones Aeronauticas, S.A. (CASA), Model CN-235, CN-235-100, CN-235-200, CN-235-300, and C-295 Airplanes
Superseded. A later AD replaced this one: AD 2010-23-05. Comply with the one in force.
This AD applies to all CASA Model CN-235, CN-235-100, CN-235-200, CN-235-300, and C-295 airplanes; certificated in any category.
We are adopting a new airworthiness directive (AD) for the products listed above. This AD results from mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:
Unless already done, do the following actions.
(1) Within 6 months after the effective date of this AD, or before December 16, 2008, whichever occurs first, revise the Airworthiness Limitations section of the Instructions for Continued Airworthiness to include the CDCCL data using a method approved in accordance with the procedures specified in paragraph (g)(1) of this AD. One approved method is EADS CASA CN-235/C-295 Technical Document DT-0-C00-05001, Issue C, dated October 2006. Where the EADS CASA technical document refers to an EADS CASA component maintenance manual (CMM), use the applicable CMM specified in Table 1 of this AD.
| CDCCL No. | CDCCL description | CMM | Revision | Date |
|---|---|---|---|---|
| 8 | Fuel pumps | Parker Hannifin CMM with Illustrated Parts List 28-22-12 (replaces CM 1C12-34) | 5 | January 10, 2008. |
| 8 | Centrifugal fuel boost pump | Parker Hannifin CMM with Illustrated Parts List CM 1C7-20, -21 (replaces CMM RR54170) | B | November 20, 2006. |
| 9 | Low level sensor | EADS CASA CMM with Illustrated Parts List 28-21-12 | 002 | June 15, 2007. |
| 10 | 3/4 ″ shutoff motorized valve | Eaton CMM with Illustrated Parts List 28-20-81 | 2 | June 20, 2006. |
| 11 | 2″ motorized spherical plug pressure relief valve | Eaton CMM with Illustrated Parts List 28-10-63 | 3 | June 20, 2006. |
| 12 | Signal conditioner | Gull CMM with Illustrated Parts List 28-40-61 | 3 | June 28, 2007. |
| 13 | Fuel control unit | Zodiac Intertechnique CMM 28-41-05 | 3 | September 25, 2006. |
Note 1: Table 1 does not include CMM 28-22-15, CE400150-E01, and C 17MQ0020-005SE, which are listed in EADS CASA CN-235/C-295 Technical Document DT-0-C00-05001, Issue C, dated October 2006. These CMM document numbers no longer apply. In addition, CMM document number 28-21-81 in EADS CASA CN-235/C-295 Technical Document DT-0-C00-05001, Issue C, dated October 2006, should be CMM document number 28-20-81.
(2) After accomplishing the actions specified in paragraph (f)(1) of this AD, no alternative CDCCLs may be used unless the CDCCLs are part of a later revision of EADS CASA CN-235/C-295 Technical Document DT-0-C00-05001, Issue C, dated October 2006, that is approved by the Manager, ANM-116, International Branch, Transport Airplane Directorate, FAA, or the European Aviation Safety Agency (EASA) (or its delegated agent); or unless the CDCCLs are approved as an alternative method of compliance (AMOC) in accordance with the procedures specified in paragraph (g)(1) of this AD.
Note 2: This AD differs from the MCAI and/or service information as follows: Although EASA Airworthiness Directive 2007-0007, dated January 9, 2007, specifies to incorporate into the aircraft maintenance program the fuel airworthiness limitation maintenance and inspection tasks defined in EADS CASA CN-235/C-295 Technical Document DT-0-C00-05001, Issue C, dated October 2006, we have not included that action. The EADS CASA Technical Document does not contain FAL maintenance and inspection tasks.
The aircraft, engines and makers this AD names, by the model designations in its text. A model listed here may still be outside the AD's serial ranges.
