Airworthiness Directive · Amendment 39-11703 · Boeing Model 737-100, -200, -300, -400, and -500 Series Airplanes
Boeing Model 737-100, -200, -300, -400, and -500 Series Airplanes
Model 737-100, -200, -300, -400, and -500 series airplanes; that are not equipped with a Grimes Aerospace taxi light assembly having part number (P/N) 50-0199-9, 50-0199-11, 50-0128-1A, 50-0128-1MA, 50-0128-3A, or 50-0128-3MA; certificated in any category.
Note 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (d) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it.
This amendment adopts a new airworthiness directive (AD), applicable to certain Boeing Model 737-100, -200, -300, -400, and -500 series airplanes, that requires repetitive inspections to detect damage of certain taxi light assemblies, and replacement with a new or serviceable part, if necessary. This AD also requires eventual replacement of certain taxi light assemblies with improved parts, which constitutes terminating action for the repetitive inspections. This amendment is prompted by a report that a damaged taxi light detached from an airplane and was ingested into the airplane engines. The actions specified by this AD are intended to prevent damage to the taxi light assembly, which could result in detachment of the taxi light assembly from the airplane, ingestion of taxi light debris into an engine, and consequent loss of thrust from one or both engines.
To prevent damage to the taxi light assembly, which could result in detachment of the taxi light from the airplane, ingestion of taxi light debris into an engine, and consequent loss of thrust from one or both engines; accomplish the following:
(a) Within 60 days after the effective date of this AD, perform a detailed visual inspection to detect damage (including cracking, corrosion, deformation, or evidence of impact) of the taxi light assembly mounted on the nose landing gear of the airplane. Repeat the inspection thereafter at intervals not to exceed 1 day, until the requirements of paragraph (c) have been accomplished.
Note 2: For the purposes of this AD, a detailed visual inspection is defined as an intensive visual inspection of a specific structural area, system, installation, or assembly to detect damage, failure, or irregularity. Available lighting is normally supplemented with a direct source of lighting at an intensity deemed appropriate by the inspector (i.e., the person performing the inspection). Inspection aids such as mirrors, magnifying glasses, etc., may be used. Surface cleaning and elaborate access procedures may be necessary.
(b) If any damage of the taxi light assembly is detected during any inspection performed in accordance with paragraph (a) of this AD, prior to further flight, replace the existing taxi light assembly with a new or serviceable taxi light assembly in accordance with the applicable maintenance manual. If the existing taxi light assembly is replaced with a Grimes Aerospace taxi light assembly having P/N 50-0199-9, 50-0199-11, 50-0128-1A, 50-0128-1MA, 50-0128-3A, or 50-0128-3MA: no further action is required by this AD.
(c) Within 2 years after the effective date of this AD: Replace the existing taxi light assembly with a Grimes Aerospace taxi light assembly having P/N 50-0199-9, 50-0199-11, 50-0128-1A, 50-0128-1MA, 50-0128-3A, or 50-0128-3MA; in accordance with the applicable maintenance manual. Such replacement constitutes terminating action for the repetitive inspection requirement of paragraph (a) of this AD.
